Product ID:5030/5040/7040/7050 TONER,4269
MSDS Date:01/05/1987
FSC:6850
NIIN:01-207-3930
Kit Part:Y
MSDS Number: BZPLD

RICOH CO LTD

1-3-6 NAKAMAGOME OTA-KU
TOKYO - JAPAN
JA

Emergency Phone: 201-582-5231

Info Phone: DITTO

Cage: S0407

RICOH CO LTD

TOKYO, VA 23508-2508 JA

Telephone: 03-777-8111JAPAN; 0559-21-2251

Cage: S0407

MINERAL SPIRITS/ISOPARAFFINIC HYDROCARBON

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 90%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ACRYLIC RESIN

Fraction By Weight: 5%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5 - 10%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9596

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- MAY CAUSE EYE IRRITATION. REPEATED/PROLONGED SKIN
CONTACT MAY CAUSE IRRITATION. HIGH VAPOR CONCENTRATIONS MAY PRODUCE
CENTRAL NERVOUS SYSTEM EF FECTS AND EYES AND RESPIRATORY TRACT
IRRITATION. INGESTION MAY CAUSE VOMITING. ASPIRATION HAZARD.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, HEADACHE, DIZZINESS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, RINSE MOUTH WITH WATER. CONSULT
PHYSICIAN.

Flash Point Method:TCC
Flash Point:106F,41C
Lower Limits:0.7
Upper Limits:6.5
Extinguishing Media:FOAM, WATER FOG, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY RUPTURE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. PICK UP SPILL WITH NON-FLAMMABLE
ABSORBENT SUCH AS SAND OR VERMICULITE. TRANSFER TO PROPER CONTAINER
FOR DISPOSAL. PREVENT LIQ UID FROM ENTERING SEWERS OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM FLAMES, SPARKS, HOT SURFACES & STRONG OXIDIZING AGENTS. KEEP
CONTAINER TIGHTLY CLOSED.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION IS HIGH, WEAR A
NIOSH-APPROVED RESPIRATOR.
Ventilation:USE EXPLOSION-PROOF VENTILATION EQUIPMENT TO CONTROL VAPOR
CONCENTRATIONS.
Protective Gloves:NEOPRENE FOR REPEATED/PROLONGED CONTACT
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:F4. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. TONER HAS PNI
A; DISPERSANT HAS PNI B, SAME NSN.

HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:356F - 374F
Vapor Pres:<10 @ 77F
Vapor Density:>5
Spec Gravity:0.78
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:BLACK LIQUID - NO ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES, SPARKS, HOT SURFACES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER DECOMPOSITION PRODUCTS MAY BE FORMED.

Waste Disposal Methods:DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH LICENSED CHEMICAL WASTE DISPOSAL SERVICE. DISCHARGE,
TREATMENT OR DISPOSAL IS SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.